china oil fired steam boiler supplier

china oil fired steam boiler supplier

Combustion gas treatment unit and a fault, gas boiler burner ignition misfire rod reasons: 1, the ignition bar gap interposed carbon residue with oil. 2, ignition rods fragmentation. moist. Leakage. 3, the distance between the ignition does not stick, too long or short. 4, ignition rods Insulation damage, short to ground. 5, ignition cable and transformer failure: cable, connector damage caused by a short circuit during ignition; transformer break or other fault occurs. Measures following five: Clear, renewal, adjust the distance, change and switching transformer. Second, gas boiler, but spark ignition rods misfire reasons: 1, the cyclone disc space ventilation is blocked carbon, poor ventilation. 2, dirty oil nozzle clogging or wear. 3, the throttle angle is set too small. 4, the firing bar from the leading edge from the oil nozzle tip inappropriate (too protruding or retracted) 5, the first solenoid valve is an oil debris blocking gun (gun small kerosene). 6, oily or too viscous to flow easily clogged or the oil filtration system the valve is not opened, so that insufficient suction pump, oil pressure. 7, the filter pump itself blocked. 8, the oil more water (boiling abnormal noise within the heater). Measures are: Clear; first wash, such as not renewed; turndown test; adjusting the distance (in 3 ~ 4mm as well); Remove cleaning (cleaning the parts diesel); Check tubing and oil filters, insulation equipment ; remove peripheral screw pump, carefully remove the cover inside out oil network, with immersion oil; renewal of the test oil. Third, when the gas boiler and turn the fire a small fire normal, off, or flashing instability reasons: 1, the air volume damper setting fire too. 2, oil fires micro switch valve (damper outermost that group) inappropriate setting (set throttle air flow rate is greater than the fire). 3, oleaginous easy to spray viscosity is too high (heavy). 4, and the nozzle plate spacing cyclone inappropriate. 5, fire nozzle worn or dirty. 6, the preliminary fuel tank temperature is too high, so that the steam not smooth oil pump oil feed. 7, fuel oil boiler water. Action: Test gradually reduced; heating temperature; adjusting the distance (between 0 ~ 10mm); clean or replace; approximately set to about 50 deg.] C; or drain oil change. Fourth, the noise increases gas boiler burner reasons: 1, cut-off valve is closed or the passage into the fuel shortage, an oil filter blockage. 2, the oil inlet temperature is low, the oil viscosity is too high or the temperature is too high the pump inlet. 3, oil pump failure. 4, fan motor bearing damage. 5, dirty fan impeller. Processing methods: ① the oil line check valve is open, if the oil filter is working properly, the filter cleaning pump itself. ② heating oil or reduce the oil temperature. ③ Replace the oil pump. ④ replace motor or bearings. ⑤ cleaning fan wheel.

The fact that we determined to achieve cooperation with the fast boiler is a very wise decision, after a period of time put into the boiler efficiency significantly much higher than our original boiler efficiency, significantly reduce fuel costs, the economic benefits brought by the boiler is obvious. --customer feedback

To get industrial gas boiler safe operation must be done to check the work of industrial gas-fired boiler pressure vessel belongs, in our country there are strict and clear standards of production and operation. In particular boiler in operation, should always pay attention to whether the safe operation of the boiler, auxiliary equipment and operation of each respective instrument valves is stable. Therefore, gas china fired steam boiler supplier room is necessary to establish a sound system of inspection tours and boiler room equipment maintenance system. First, natural gas boiler room mobile inspection system 1, in order to ensure the normal operation of the boiler and its accessory equipment, timely detection of problems, fireman on duty personnel at least once every half hour tour inspection. 2. Check gas boiler burners, pressure gauge, thermometer, circulation pump, water supply pump, water softening, safety accessories, an instrument, secondary instrument is functioning properly. 3, check whether the abnormal changes in various types of signal lights. 4, check the water level in the tank gas boiler, feed pumps, circulating pump and motor bearing temperature and pump lubricating parts are normal. 5, check the position of the gas valve and the steam boiler feedwater pressure switch valve is normal. 6, mobile inspection found problems in time, and test results recorded in the log boiler and accessory equipment inside. Second, gas-fired equipment maintenance system 1, two gas-fired boiler on the pressure gauge value is not the same timely maintenance, to ensure reflect the actual operation of the boiler pressure. 2, gas boiler pressure gauge damage, when the dial is not clear, timely replacement. 3, rotating machinery lubricating oil passage remains open, the oil cup to maintain a certain oil level. 4, run, run, drip, leak repair valves can be repaired, replaced. 5, inspection, maintenance and feed pumps, circulating pumps and pump valves open is flexible, single-stream if the door is closed tight. 6. Check the gas-fired secondary instrument is normal. 7, to remove dust on the equipment and the accessory device. 8, check the gas boiler safety valve manually turn on the water after closed trials are tight. Automatically turn on the water, blowing off steam at least once a week. 9, pressure gauges operate properly flushed at least once a week. Trap maintenance once a month. 10, over-temperature, overpressure alarms, overpressure interlock device checks at least once a month, and maintenance. Gas boiler pressure gauge, water level gauge and a safety valve are the three safety accessories on the gas steam boiler, with particular attention.

Gas-fired china fired steam boiler supplier safe operation Tidbits gas steam boiler safe operation Tips 1. The operator should be familiar with the structure and principles of the furnace and the production of basic requirements for thermal equipment, and constantly sum up experience in practice, control coal thickness, so that the full combustion reduce chimney smoke, protect the equipment in a safe, efficient operation. 2. The new oil furnace or restart long home, gas steam shall dehydration stage heating requirements. 3. export oil temperature should be set below 280 ℃, when the oil temperature exceeds 200 ℃, should pay more attention to temperature, oil temperature should slow down, only non-oil change and over-temperature operation. 4. close contact with production, timely and slow down the oil temperature, while meeting production requirements, taking oil lower, will help extend the life of gas and steam energy savings. The normal oil level: the lower tank oil level is low, high-high oil groove. This ensures that the emergency shutdown when cold oil replacement system and prevents air from entering the pipe. When the high slot in a low oil level should start to replenish gas steam injection pump. 6. The circulation pump is allowed outage in the operation of the burner, when the pump is failure or power outage, Fan stop, depending on oil temperature and take appropriate emergency measures: rapid opening valve 7, the cold head tank oil up through the furnace coils to the low tank. 8. Coal and wet coal hearth fire or discharge out of the furnace, non-water washed pouring furnace. These measures should be completed within 3 to 5 minutes, to prevent the high oil temperature coke deposits other accidents. 9. normal shutdown, the oil temperature should be reduced to below 100 ℃, stop the pump before. 10. When the outlet pressure differential below the set value, the induced draft fan should outage. Then there is a fault system, feedback should be immediately removed or, if necessary, should pressure fire outage. 11. fireman should stick to their posts, do a good job operating records and shift work, and regular inspection and maintenance equipment.

china oil fired steam boiler supplier Related Information

China Industrial Packaged Coal Fired Travelling Grate

China Industrial Packaged Coal Fired Travelling Grate Steam Boiler1-35tph, Find details about China Boiler, Packed Boiler from Industrial Packaged Coal Fired Travelling Grate Steam Boiler1-35tph - QINGDAO HAMMER INDUSTRIES CO., LTD.

Get a Quote

China Gas Oil Fired Steam Boiler, China Gas Oil Fired

And whether gas oil fired steam boiler is vertical. There are 26,151 gas oil fired steam boiler suppliers, mainly located in Asia. The top supplying country or region is China, which supply 100% of gas oil fired steam boiler respectively. Gas oil fired steam boiler products are most popular in United States, Indonesia, and Ethiopia.

Get a Quote

Chinese Marine Boiler with Ce - China Marine Boiler,

Marine Boiler, Steam Boiler, Heater manufacturer / supplier in China, offering Chinese Marine Boiler with Ce, High Quality Oil Fired Steam Marine Boiler, Flt Marine Exhaust Gas Boiler and so on.

Get a Quote

Quality Gas Fired Steam Boiler & Oil Fired Steam

Zhangjiagang Wilford Thermal Co.,Ltd. is best Gas Fired Steam Boiler, Oil Fired Steam Boiler and Industrial Electric Steam Boiler supplier, we has good quality products & service from China.

Get a Quote

China Diesel Steam Boiler, China Diesel Steam Boiler

China Diesel Steam Boiler, China Diesel Steam Boiler Suppliers and Manufacturers Directory - Source a Large Selection of Diesel Steam Boiler Products at steam boiler,electric steam boiler,oil steam boiler from China Alibaba.com

Get a Quote

China Boiler manufacturer, Steam Boiler, Hot Water

Boiler, Steam Boiler, Hot Water Boiler manufacturer / supplier in China, offering Horizontal Single-Drum Industrial Coal Fired Steam Boiler, Fuel Gas, Diesel, Heavy Oil Steam Boiler, Horizontal Style Steam or Hot Water Output Oil Boiler and so on.

Get a Quote

heavy oil fired steam boiler hotel_ZOZEN

heavy oil fired steam boiler hotel. ZOZEN Boiler provides you with 24-hour comprehensive after-sales service. ZOZEN. Low noise hot water boiler for hotel / bathroom / Greenhouse gas combi boiler. 70 years history factory supply diesel oil and city gas fired boiler for hotel heating.

Get a Quote

China Oil and Gas Fired Steam Boiler - China Steam

Steam Boiler, Gas Boiler, Oil Boiler manufacturer / supplier in China, offering Oil and Gas Fired Steam Boiler, Horizontal Single-Drum Industrial Coal Fired Steam Boiler, Fuel Gas, Diesel, Heavy Oil Steam Boiler

Get a Quote

China Gas Boiler, Steam Boiler, Coal Boiler Supplier

China Gas Boiler Supplier, Steam Boiler, Coal Boiler Manufacturers/ Suppliers - Henan Yuanda Boiler Corporation Ltd. Henan Yuanda Boiler Corporation Ltd. Diamond Member. Audited Supplier. Zhoukou, Henan, China. Member Since: 2016. Wns3-1.25-Yq 3 Ton Hr Gas Diesel Furnace Oil Fired Steam Boiler for Fruit Juice Factory.

Get a Quote

China Pellet Hot Water Boiler - China Boiler, Biomass

Boiler, Biomass, Hot Water Boiler manufacturer / supplier in China, offering Pellet Hot Water Boiler, High Thermal Efficiency 50kg/H Gas Fired Steam Generator for Hospital, School, Chemical Plant Disinfection, High Thermal Efficiency 50kg/H Gas Fired Steam Generator for Sandwich Pot and so on.

Get a Quote

heavy oil fired steam boiler hotel_ZOZEN

heavy oil fired steam boiler hotel. ZOZEN Boiler provides you with 24-hour comprehensive after-sales service. ZOZEN. Low noise hot water boiler for hotel / bathroom / Greenhouse gas combi boiler. 70 years history factory supply diesel oil and city gas fired boiler for hotel heating.

Get a Quote

heavy oil fired steam boiler hotel_ZOZEN

heavy oil fired steam boiler hotel. ZOZEN Boiler provides you with 24-hour comprehensive after-sales service. ZOZEN. Low noise hot water boiler for hotel / bathroom / Greenhouse gas combi boiler. 70 years history factory supply diesel oil and city gas fired boiler for hotel heating.

Get a Quote

China Industrial Packaged Coal Fired Travelling Grate

China Industrial Packaged Coal Fired Travelling Grate Steam Boiler1-35tph, Find details about China Boiler, Packed Boiler from Industrial Packaged Coal Fired Travelling Grate Steam Boiler1-35tph - QINGDAO HAMMER INDUSTRIES CO., LTD.

Get a Quote

china wns steam boiler supplier - franziskaner-garten.de

China Factory Price Wns Steam Boiler for Industry - Propane Boiler, Fire Tube Heater, Boiler Parts manufacturer / supplier in China, offering China Factory Price Wns Steam Boiler for Industry, Adequate Heating Oil Gas Fired Steam Boiler for Laundry Factory, Oil/Gas Steam Generator Boiler for Beer Brewing System and so on.

Get a Quote

Quality Gas Fired Steam Boiler & Oil Fired Steam

Yong Xing Boiler Group Co.,Ltd is best Gas Fired Steam Boiler, Oil Fired Steam Boiler and Biomass Fired Steam Boiler supplier, we has good quality products & service from China.

Get a Quote

Do You Want To Get An Exclusive Project Plan ?

7 * 24 * 365 endless service, click the button to provide you with professional and fast solutions at any time

Scroll to Top